Degradation of polyacrylamide (PAM) and methane production by mesophilic and thermophilic anaerobic digestion: Effect of temperature and concentration

• PAM degradation in thermophilic AD in comparison with mesophilic AD. • PAM degradation and its impact on thermophilic and mesophilic AD. • Enhanced methane yield in presence of PAM during thermophilic and mesophilic AD. • PAM degradation and microbial community analysis in thermophilic and mesophilic AD. Polyacrylamide (PAM) is generally employed in wastewater treatment processes such as sludge dewatering and therefore exists in the sludge. Furthermore, it degrades slowly and can deteriorate methane yield during anaerobic digestion (AD). The impact or fate of PAM in AD under thermophilic conditions is still unclear. This study mainly focuses on PAM degradation and enhanced methane production from PAM-added sludge during 15 days of thermophilic (55°C) AD compared to mesophilic (35°C) AD. Sludge and PAM dose from 10 to 50 g/kg TSS were used. The results showed that PAM degraded by 76% to 78% with acrylamide (AM) content of 0.2 to 3.3 mg/L in thermophilic AD. However, it degraded only 27% to 30% with AM content of 0.5 to 7.2 mg/L in mesophilic AD. The methane yield was almost 230 to 238.4 mL/g VSS on the 8th day in thermophilic AD but was 115.2 to 128.6 mL/g VSS in mesophilic AD. Mechanism investigation revealed that thermophilic AD with continuous stirring not only enhanced PAM degradation but also boosted the organics release from the sludge with added PAM and gave higher methane yield than mesophilic AD.     

SMBBR-AF-SMBBR组合工艺处理高氨氮农药废水

采用特异性移动床生物膜反应器(SMBBR)和厌氧生物滤池(AF)组合工艺处理高氨氮农药废水。考察了HRT、pH和DO等工艺条件对SMBBR-AF-SMBBR组合工艺运行稳定期COD和氨氮去除率的影响。试验结果表明,在进水COD为2 408~7 440 mg/L、ρ(NH_4~+-N)为160.21~433.84 mg/L、TN为208.27~537.65 mg/L、HRT为8d、pH为8.0、DO为4 mg/L的条件下,处理后出水平均COD为342 mg/L,COD去除率达92.3%;ρ(NH_4~+-N)小于4.0mg/L,氨氮平均去除率为89.2%;TN小于50 mg/L,平均TN去除达83.0%。出水各指标均优于原A2O工艺出水。     

Aerobic treatment of swine manure to enhance anaerobic digestion and microalgal cultivation

Aerobic treatment of swine manure was coupled with anaerobic digestion and microalgal cultivation. A 14-day aerobic treatment reduced the total solid content of swine manure by >15%. Ammonia and carbon dioxide were stripped by the air supplied, and this off-gas was further used to aerate the culture of Chlorella vulgaris. The microalgal growth rates in Bristol medium and the wastewater with the off-gas increased from 0.08 to 0.22 g/L/d and from 0.15 to 0.24 g/L/d, respectively. Meanwhile, the aerobically treated swine manure showed a higher methane yield during anaerobic digestion. The experimental results were used to establish a demonstration unit consisting of a 100 L composter, a 200 L anaerobic digester, a 60 L tubular photobioreactor, and a 300 L micro-open raceway pond.     

水中总氮测定方法存在问题的研究及改进

碱性过硫酸钾消解紫外分光光度法测定水中总氮采用的消解器皿是玻璃比色管,易造成空白偏高、结果偏低等问题。采用双圆柱状的消解杯对水样进行消解。结果表明,消解杯消解水中总氮,线性相关系数均大于0.999,检出限为0.05 mg/L,相对标准偏差小于5%,相对误差为0.88%~1.00%;改进后的消解器皿具有较好的精密度和准确度,能够更加准确测定水中总氮的含量。     

AMBBR工艺处理城市污水

通过对厌氧移动床生物膜反应器处理南方热带亚热带地区城市生活污水的试验研究,采用好氧-厌氧两个阶段进行挂膜试验以缩短挂膜时间,探讨了水力停留时间(HRT)、pH值、填料填充率对反应器处理效果的影响。试验结果表明:在HRT为12 h,进水ρ(COD)为300 mg/L,ρ(氨氮)为15 mg/L,50%的填料填充率,pH=7的工艺条件下,装置对COD去除率为51.2%,对氨氮去除率为40.8%,对TN去除率为38.1%。     

有机固体废弃物厌氧干发酵机制研究进展

利用厌氧干发酵技术处理固体有机废物与传统的湿发酵相比具有许多优势,但厌氧干发酵机制的研究存在许多困难,在一定程度上限制了厌氧干发酵技术的发展。文章在对国内外研究现状进行文献调查后,总结概括了厌氧干发酵理论模型从"两点模型"和"区反应模型"到"浓度波扩散模型"和"反应前沿假说"的发展进程,讨论了其各自特点和对厌氧干发酵机制研究的意义以及其不完善之处;并分别从微生物生长、底物水解和生物气产生三个方面综述了近年来国内外对厌氧干发酵动力学的研究进展。然而,目前的研究仅是针对某些物料进行的特异性研究,还没有一个普遍适用的关于有机固体废弃物厌氧干发酵的理论模型被发展出来,因此对干发酵传质传热机制的探索和数学模拟成为当前对于干发酵机制研究的主要方向。     

厌氧生物滴滤法脱除冷煤气中硫化氢的研究

水煤气中硫化氢在燃烧时会转变成二氧化硫,对环境产生污染。文章采用厌氧生物滴滤塔法对冷煤气进行脱硫处理。因煤气对氧的严格限制,通过设计生物滴滤塔,经挂膜驯化后在厌氧条件下对浓度在1~5 g/m3左右的硫化氢进行脱除处理,考察滴滤塔运行条件对脱除效果的影响。结果表明,生物挂膜25 d后,生物滴滤塔达到稳定,喷淋液pH值为2.23,ORP值为283 mV,溶解氧为0.4 mg/L,对溶液中硫离子氧化效率达到94%。滴滤塔在液气比0.15,空塔气速0.088 m/s,pH值5.0~7.0,填料高度为82 cm,塔温为25~30℃左右时,达到较优的运行条件,此时该滴滤塔对以CO、CO2、H2和1 940 mg/m3H2S组成的模拟水煤气的脱硫效率达91.2%。     

不同堆沤处理对玉米秸秆厌氧发酵的影响

研究利用纤维素分解菌F2对玉米秸秆进行堆沤预处理,将经不同堆沤预处理时间后的秸秆与猪粪混合进行厌氧发酵产沼气试验。结果发现,堆沤15 d后秸秆的总有机碳含量降低了10.06%,VS去除率和纤维素降解率比未加菌堆沤预处理分别提高了10.74%、10.60%;加菌堆沤预处理后的秸秆厌氧发酵甲烷产气率、干物质产气率、发酵前后VS去除率均高于未加菌堆沤预处理后的秸秆,且产气效率也有明显的提高;加菌堆沤预处理10 d的秸秆比未加菌堆沤预处理15 d的秸秆提前了2 d达到产气高峰,累计产气量达到21 957 mL,比未加菌堆沤预处理15 d的秸秆增加了1 629 mL。实验结果表明:该纤维素分解菌对玉米秸秆纤维素有较强的降解能力,并在一定程度上促进了有机碳的矿化;有效地提高了秸秆的生物降解性能,缩短了预处理所需时间;同时提高了玉米秸秆的利用率和产气潜力。     

手提式蒸汽消毒器同时消解总磷总氮实验分析

水体中总磷、总氮的增多,会造成藻类的滋生,使水环境质量降低。因此,对总磷、总氮的监测十分必要。国标方法测定水中总磷总氮,都要用手提式蒸汽消毒器进行消解,且消解温度和时间相同。为建立一种快速的测定方法,将总磷、总氮同时放入蒸汽消毒器中进行消解,将此方法与标准消解法进行了对比分析。结果表明:同时消解法的精密度、准确度、回收率、工作曲线等均符合总磷总氮的测定要求,标准物质的测定结果和相对误差均在规范范围内,说明此方法可靠。在总磷、总氮都需检测时,大大缩短了实验时间,减少了蒸汽消毒器的使用频率,是一种快速、简便测定水中总磷总氮的方法。     

不同载体材料对厌氧氨氧化效果影响的研究

文章分别采用水性聚氨酯(WPU)和活性炭2种材料作为生物载体,在2个不同的上流式厌氧污泥床(UASB)反应器中接种包埋污泥和生物活性炭,采用人工配水进行连续实验,观测厌氧氨氧化反应器启动过程中各种含氮化合物的变化,以考察不同载体材料对厌氧氨氧化过程的影响。文章在生物活性炭反应器中成功驯化了采自污水处理厂的普通厌氧污泥,证明了从环境中驯化培养厌氧氨氧化菌的可能性。通过2个阶段中脱氮效率的比较,发现以水性聚氨酯包埋材料作为未驯化细菌载体并无明显优势,反而成为传质的障碍;而采用生物活性炭则可以迅速达到提高局部生物量、聚集功能菌、屏蔽不利环境的干扰等作用,是理想的微生物载体。